Boiler and Oil Burner Tune-Ups in Port Jefferson Station, NY
Most no-heat calls in January start as small problems in September. A yearly tune-up keeps your boiler clean, safe, and ready for winter. True Quality Plumbing and Heating services oil and gas boilers across Port Jeff Station and nearby towns.
Why Your Boiler Needs a Yearly Tune-Up
An oil burner makes soot every time it runs. Over a winter, that soot coats the inside of the boiler. Heat that should go into your water goes up the chimney instead. The nozzle wears. The filter clogs. Small problems pile up until the burner quits on the coldest night of the year.
A tune-up fixes that before it happens:
- Fewer breakdowns. Worn parts get replaced before they fail.
- Less wasted fuel. A clean boiler moves more heat into your home.
- Safer. We check for soot, leaks, and carbon monoxide risks.
- Longer life. A clean, well-tuned boiler lasts longer.
What We Do During an Oil Burner Tune-Up
Cleaning
- Remove and clean the flue pipe that runs to the chimney
- Check the chimney opening for blockages
- Brush the soot out of the boiler's heat passages
- Clean the combustion chamber and check its lining
Burner service
- Replace the oil nozzle
- Replace the oil filter
- Clean the oil pump screen
- Set the electrodes that make the spark
- Clean the flame sensor
- Check the oil pump pressure
- Check oil lines and fittings for leaks
Testing
- Test the combustion with a meter: draft, smoke, oxygen, and stack temperature
- Adjust the burner for a clean, efficient flame
- Test the safety controls and the relief valve
- Check system pressure and the expansion tank
- Check the pumps and zone valves
Wrap-up
- Clean up any oil or soot
- Fire the boiler through a full cycle
- Tell you what we found and if anything needs attention
Gas Boiler Tune-Ups
Gas boilers burn cleaner than oil, but they still need checking. We inspect the burner and igniter, clean the flame sensor, check the venting, test the safety controls, and look for leaks. High-efficiency boilers also need their condensate drain and neutralizer checked so they don't shut down.
We Test It, Not Just Clean It
Changing a nozzle and leaving isn't a tune-up. We use a combustion meter to measure how your burner is actually running. Then we adjust it for a clean flame with a little safety margin for the changing weather. You'll know your boiler is running right, not just guessing.
When to Schedule Your Tune-Up
September and October are the best time. Your boiler has rested all summer, and you'll catch problems before the first cold night.
Already into the heating season? A tune-up still helps. Call any time.
Signs you're overdue:
- It's been more than a year since your last service
- Soot around the boiler or on the wall behind it
- An oil smell in the basement
- The burner is louder, rumbling, or slow to light
- Fuel use went up
- The red reset button has tripped
Don't Have an Oil Company Contract?
On Long Island, a lot of people get their burner serviced through the company that delivers their oil. You don't need a contract to get a tune-up. If you buy oil from a discount dealer, or you just want a licensed plumber to look at your system, call us.
Good to Do at the Same Time
Hose Bib Winterizing
Shut off and drain your outdoor faucets and outdoor shower before the first freeze.
Water Heater Check
Flush the tank, check the relief valve, and look for early signs of leaks. See our Water Heater Replacement page.
Carbon Monoxide Alarm Check
Make sure you have working CO alarms near sleeping areas and on each level.
See Water Heater Replacement for more on water heater service.
Heating Tune-Ups Near You
We tune up boilers in Port Jefferson Station, Terryville, Port Jefferson, East Setauket, Setauket, Mount Sinai, Coram, and Selden.
Most homes around here heat with an oil boiler and baseboard, many from the 1960s and 70s. Older boilers are less forgiving. A dirty one wastes more fuel and fails more often. A yearly tune-up keeps them going.
Tune-Up Questions
Schedule Your Heating Tune-Up
Call True Quality Plumbing and Heating. Licensed master plumber in Port Jefferson Station.